Page Header

Home > Vol 17, No 1 (Jan.–Mar. 2024) > Van Anh

Utilization of Rice Husk and Alum Sludge to Produce an Efficient Adsorbent Composite for Recovery of Nutrients from Wastewater

Nguyen Thi Van Anh, Nguyen Ngoc Hoa, Nguyen Thi Thuy, Nguyen Lan Thanh, Nguyen Nhat Huy

Abstract


This study focused on developing an adsorbent composite from rice husk and alum sludge to recover nutrients from wastewater, which could be used in the future for slow-release fertilizer production. A biochar-sludge composite (80B/20S) was created by modifying rice husk biochar with MgCl2 and using acid- and heat-treated alum sludge to extract ammonium and phosphate contents from wastewater. The physical and chemical properties of the materials were analyzed using various techniques, such as X-ray diffraction and scanning electron microscopy. In the nutrient recovery test, the contact time, adsorbent dosage, and initial concentration were evaluated. The adsorption equilibrium contact time for both ammonium and phosphate were found to be 8 h, and the maximum adsorption capacity by Langmuir isotherm for the 80B/20S composite was 185.53 mgNH4 +/g and 63.78 mgPO4 3-/g. The composite material had a higher surface area of 141.32 m2/g, which promoted its adsorption capacity. Additionally, this material demonstrated a removal efficiency above 85% when applied to actual wastewater. Since the composite is composed mainly of natural components, it has the potential to be used as a sustainable slow-release fertilizer for agricultural growth.

Keywords



[1] Q. Yin, M. Liu, and H. Ren, “Removal of ammonium and phosphate from water by Mg-modified biochar: Influence of Mg pretreatment and pyrolysis temperature,” BioResources, vol. 14, pp. 6203–6218, 2019.

 

[2] H. Zhang, R. Voroney, and G. Price, “Effects of temperature and activation on biochar chemical properties and their impact on ammonium, nitrate, and phosphate sorption,” Journal of Environmental Quality, vol. 46, pp. 889–896, 2017.

 

[3] P. T. Phan, T. T. Nguyen, N. H. Nguyen, and S. Padungthon, “Triamine-bearing activated rice husk ash as an advanced functional material for nitrate removal from aqueous solution,” Water Science and Technology, vol. 79, pp. 850–856, 2019.

 

[4] Y. Yao, B. Gao, M. Inyang, A. R. Zimmerman, X. Cao, P. Pullammanappallil, and L. Yang, “Removal of phosphate from aqueous solution by biochar derived from anaerobically digested sugar beet tailings,” Journal of Hazardous Materials, vol. 190, pp. 501–507, 2011.

 

[5] M. Zhang, B. Gao, Y. Yao, Y. Xue, and M. Inyang, “Synthesis of porous MgO-biochar nanocomposites for removal of phosphate and nitrate from aqueous solutions,” Chemical Engineering Journal, vol. 210, pp. 26–32, 2012.

 

[6] Z. Wang, H. Guo, F. Shen, G. Yang, Y. Zhang, Y. Zeng, L. Wang, H. Xiao, and S. Deng, “Biochar produced from oak sawdust by Lanthanum (La)-involved pyrolysis for adsorption of ammonium (NH4+), nitrate (NO3−), and phosphate (PO43−),” Chemosphere, vol. 119, pp. 646–653, 2015.

 

[7] S. Wan, S. Wang, Y. Li, and B. Gao, “Functionalizing biochar with Mg–Al and Mg–Fe layered double hydroxides for removal of phosphate from aqueous solutions,” Journal of Industrial and Engineering Chemistry, vol. 47, pp. 246–253, 2017.

 

[8] T. Sizmur, T. Fresno, G. Akgül, H. Frost, and E. Moreno-Jiménez, “Biochar modification to enhance sorption of inorganics from water,” Bioresource Technology, vol. 246, pp. 34–47, 2017.

 

[9] L. He, D. Wang, Z. Wu, Y. Lv, and S. Li, “Magnesium-modified biochar was used to adsorb phosphorus from wastewater and used as a phosphorus source to be recycled to reduce the ammonia nitrogen of piggery digestive wastewater,” Journal of Cleaner Production, vol. 360, 2022, Art. no. 132130.

 

[10] R. Xiao, H. Zhang, Z. Tu, R. Li, S. Li, Z. Xu, and Z. Zhang, “Enhanced removal of phosphate and ammonium by MgO-biochar composites with NH(3)·H(2)O hydrolysis pretreatment,” Environmental Science and Pollution Research, vol. 27, pp. 7493–7503, 2020.

 

[11] R. Li, J. J. Wang, B. Zhou, Z. Zhang, S. Liu, S. Lei, and R. Xiao, “Simultaneous capture removal of phosphate, ammonium and organic substances by MgO impregnated biochar and its potential use in swine wastewater treatment,” Journal of Cleaner Production, vol. 147, pp. 96–107, 2017.

 

[12] C. C. Hollister, J. J. Bisogni, and J. Lehmann, “Ammonium, nitrate, and phosphate sorption to and solute leaching from biochars prepared from corn stover (Zea mays L.) and oak wood (Quercus spp.),” Journal of Environmental Quality, vol. 42, pp. 137–144, 2013.

 

[13] Y. Yao, B. Gao, M. Inyang, A. R. Zimmerman, X. Cao, P. Pullammanappallil, and L. Yang, “Biochar derived from anaerobically digested sugar beet tailings: Characterization and phosphate removal potential,” Bioresource Technology, vol. 102, pp. 6273–6278, 2011.

 

[14] D. Jiang, B. Chu, Y. Amano, and M. Machida, “Removal and recovery of phosphate from water by Mg-laden biochar: Batch and column studies,” Colloids and Surfaces A: Physicochemical and Engineering Aspects, vol. 558, pp. 429–437, 2018.

 

[15] K. Butterbach‐Bahl, D. Kraus, R. Kiese, V. T. Mai, T. Nguyen, B. O. Sander, R. Wassmann, and C. Werner, “Activity data on crop management define uncertainty of CH4 and N2O emission estimates from rice: A case study of Vietnam,” Journal of Plant Nutrition and Soil Science, vol. 185, pp. 793–806, 2022.

 

[16] M. Keck and D. T. Hung, “Burn or bury? A comparative cost–benefit analysis of crop residue management practices among smallholder rice farmers in northern Vietnam,” Sustainability Science, vol. 14, pp. 375–389, 2018.

 

[17] P. T. Duong and H. Yoshiro, “Current situation and possibilities of rice straw management in Vietnam,” University of Tsukuba, Ibaraki, Japan, 2015.

 

[18] N. T. T. Truc, Z. M. Sumalde, M. V. O. Espaldon, E. P. Pacardo, C. L. Rapera, and F. G. Palis, “Farmers’ awareness and factors affecting adoption of rapid composting in Mekong Delta, Vietnam and Central Luzon, Philippines,” Journal of Environmental Science Management and Compliance Series, vol. 15, no. 2, pp. 59–73, 2012.

 

[19] SNV, “Biomass business opportunities in Vietnam,” 2012. [Online]. Available: http://www. snvworld.org/en/vietnam/publications/biomass-business-opportunities-in-vietnam

 

[20] T. Q. Cong and D. N. Hien, “Feasibility of cleaner production for vietnam rice processing industry,” Procedia CIRP, vol. 40, pp. 285–288, 2016.

 

[21] B. Bushra and N. Remya, “Biochar from pyrolysis of rice husk biomass—characteristics, modification and environmental application,” Biomass Conversion and Biorefinery, 2020.

 

[22] K. Simon, W. Shubiao, W, L. Ming, L. Qimin, B. Hamidou, and D. Renjie, “Evaluation of slow pyrolyzed wood and rice husks biochar for adsorption of ammonium nitrogen from piggery manure anaerobic digestate slurry,” Science of the Total Environment, vol. 505, pp. 102–112, 2015.

 

[23] K. Herrera, L. F. Morales, N. A. Tarazona, R. Aguado, and J. F. Saldarriaga, “Use of biochar from rice husk pyrolysis: Part A: Recovery as an adsorbent in the removal of emerging compounds,” ACS Omega, vol. 7, pp. 7625–7637, Mar. 2022.

 

[24] A. A. H. Saeed, N. Y. Harun, M. M. Nasef, A. Al-Fakih, A. A. S. Ghaleb, and H. K. Afolabi, “Removal of cadmium from aqueous solution by optimized rice husk biochar using response surface methodology,” Ain Shams Engineering Journal, vol. 13, vol. 13, no. 1, 2022, Art. no. 101516.

 

[25] Q. Yin, B. Zhang, R. Wang, and Z. Zhao, “Biochar as an adsorbent for inorganic nitrogen and phosphorus removal from water: A review,” Environmental Science and Pollution Research, vol. 24, pp. 26297–26309, 2017.

 

[26] R. Singh and M. Agrawal, “Potential benefits and risks of land application of sewage sludge,” Waste Management, vol. 28, pp. 347–358, 2008.

 

[27] Y. Yang, Y. Zhao, A. Babatunde, L. Wang, Y. Ren, and Y. Han, “Characteristics and mechanisms of phosphate adsorption on dewatered alum sludge,” Separation and Purification Technology, vol. 51, pp. 193–200, 2006.

 

[28] A. Babatunde, Y. Yang, and Y. Zhao, “Towards the development of a novel wastewater treatment system incorporating drinking water residual: Preliminary results,” in 10th European Biosolids Conference, 2005.

 

[29] J. G. Kim, J. H. Kim, H.-S. Moon, C.-M. Chon, and J. S. Ahn, “Removal capacity of water plant alum sludge for phosphorus in aqueous solutions,” Chemical Speciation & Bioavailability, vol. 14, pp. 67–73, 2002.

 

[30] A. Babatunde and Y. Zhao, “Equilibrium and kinetic analysis of phosphorus adsorption from aqueous solution using waste alum sludge,” Journal of Hazardous Materials, vol. 184, pp. 746–752, 2010.

 

[31] M. Kończak and M. Huber, “Application of the engineered sewage sludge-derived biochar to minimize water eutrophication by removal of ammonium and phosphate ions from water,” Journal of Cleaner Production, vol. 331, 2022, Art. no. 129994.

 

[32] Q. He, X. Li, and Y. Ren, “Analysis of the simultaneous adsorption mechanism of ammonium and phosphate on magnesium-modified biochar and the slow release effect of fertiliser,” Biochar, vol. 4, 2022, Art. no. 25.

 

[33] Y. H. Jiang, A. Y. Li, H. Deng, C. H. Ye, Y. Q. Wu, Y. D. Linmu, and H. L. Hang, “Characteristics of nitrogen and phosphorus adsorption by Mg-loaded biochar from different feedstocks,” Bioresource Technology, vol. 276, pp. 183–189, 2019.

 

[34] C. A. Takaya, L. A. Fletcher, S. Singh, K. U. Anyikude, and A. B. Ross, “Phosphate and ammonium sorption capacity of biochar and hydrochar from different wastes,” Chemosphere, vol. 145, pp. 518–527, 2016.

 

[35] G. A. Adebisi, Z. Z. Chowdhury, and P. A. Alaba, “Equilibrium, kinetic, and thermodynamic studies of lead ion and zinc ion adsorption from aqueous solution onto activated carbon prepared from palm oil mill effluent,” Journal of Cleaner Production, vol. 148, pp. 958–968, 2017.

 

[36] Y. Zhao, Y. Yang, S. Yang, Q. Wang, C. Feng, and Z. Zhang, “Adsorption of high ammonium nitrogen from wastewater using a novel ceramic adsorbent and the evaluation of the ammonium-adsorbed-ceramic as fertilizer,” Journal of Colloid and Interface Science, vol. 393, pp. 264–270, 2013.

 

[37] G. Peng, S. Jiang, Y. Wang, Q. Zhang, Y. Cao, Y. Sun, W. Zhang, and L. Wang, “Synthesis of Mn/Al double oxygen biochar from dewatered sludge for enhancing phosphate removal,” Journal of Cleaner Production, vol. 251, 2020, Art. no. 119725.

 

[38] R. Li, J. J. Wang, B. Zhou, M. K. Awasthi, A. Ali, Z. Zhang, L. A. Gaston, A. H. Lahori, and A. Mahar, “Enhancing phosphate adsorption by Mg/Al layered double hydroxide functionalized biochar with different Mg/Al ratios,” The Science of the Total Environment, vol. 559, pp. 121–129, 2016.

 

[39] Z. Danchen, Y. Haiping, C. Xu, C. Wei, C. Ning, C. Yingquan, Z. Shihong, and C. Hanping, “Temperature-dependent magnesium citrate modified formation of MgO nanoparticles biochar composites with efficient phosphate removal,” Chemosphere, vol. 274, 2021, Art. no. 129904.

 

[40] M. M. T. Zin and D. J. Kim, “Simultaneous recovery of phosphorus and nitrogen from sewage sludge ash and food wastewater as struvite by Mg-biochar,” Journal of Hazardous Materials, vol. 403, 2021, Art. no. 123704.

 

[41] Z. Zeng, T.-q. Li, F.-l. Zhao, Z.-l. He, H.-p. Zhao, X.-e. Yang, H.-l. Wang, J. Zhao, and M. T. Rafiq, “Sorption of ammonium and phosphate from aqueous solution by biochar derived from phytoremediation plants,” Journal of Zhejiang University Science B, vol. 14, pp. 1152–1161, 2013.

 

[42] D. Luo, L. Wang, H. Nan, Y. Cao, H. Wang, T. V. Kumar, and C. Wang, “Phosphorus adsorption by functionalized biochar: A review,” Environmental Chemistry Letters, vol. 21, pp. 497–524, 2022.

 

[43] L. Dai, B. Wu, F. Tan, M. He, W. Wang, H. Qin, X. Tang, Q. Zhu, K. Pan, and Q. Hu, “Engineered hydrochar composites for phosphorus removal/ recovery: Lanthanum doped hydrochar prepared by hydrothermal carbonization of lanthanum pretreated rice straw,” Bioresource Technology vol. 161, pp. 327–332, 2014.

 

[44] H. Liu, Y. Dong, H. Wang, and Y. Liu, “Ammonium adsorption from aqueous solutions by strawberry leaf powder: Equilibrium, kinetics and effects of coexisting ions,” Desalination, vol. 263, pp. 70–75, 2010.

 

[45] Z. Wang, D. Shen, F. Shen, and T. Li, “Phosphate adsorption on lanthanum loaded biochar,” Chemosphere, vol. 150, pp. 1–7, 2016.

 

[46] N. Cheng, B. Wang, Q. Feng, X. Zhang, and M. Chen, “Co-adsorption performance and mechanism of nitrogen and phosphorus onto eupatorium adenophorum biochar in water,” Bioresource Technology, vol. 340, 2021, Art. no. 125696.

 

[47] H. Cruz, P. Luckman, T. Seviour, W. Verstraete, B. Laycock, and I. Pikaar, “Rapid removal of ammonium from domestic wastewater using polymer hydrogels,” Scientific Reports, vol. 8, pp. 1–6, 2018.

 

[48] J. Pesonen, P. Myllymäki, S. Tuomikoski, G. Vervecken, T. Hu, H. Prokkola, P. Tynjälä, and U. Lassi, “Use of calcined dolomite as chemical precipitant in the simultaneous removal of ammonium and phosphate from synthetic wastewater and from agricultural sludge,” ChemEngineering, vol. 3, 2019, Art. no. 40.

 

[49] B. Wu, L. Fang, J. D. Fortner, X. Guan, and I. M. Lo, “Highly efficient and selective phosphate removal from wastewater by magnetically recoverable La(OH)3/Fe3O4 nanocomposites,” Water Research, vol. 126, pp. 179–188, 2017.

 

[50] Q. Yin, R. Wang, and Z. Zhao, “Application of Mg–Al-modified biochar for simultaneous removal of ammonium, nitrate, and phosphate from eutrophic water,” Journal of Cleaner Production, vol. 176, pp. 230–240, 2018.

 

[51] Z. Ming, G. Bin, Y. Ying, and I. Mandu, “Phosphate removal ability of biochar/MgAl-LDH ultra-fine composites prepared by liquid-phase deposition,” Chemosphere, vol. 92, pp. 1042–1047, 2013.

 

[52] T. Li, X. Su, X. Yu, H. Song, Y. Zhu, and Y. Zhang, “La(OH)3-modified magnetic pineapple biochar as novel adsorbents for efficient phosphate removal,” Bioresource Technology, vol. 263, pp. 207–213, 2018.

 

[53] L. Xue, B. Gao, Y. Wan, J. Fang, S. Wang, Y. Li, R. Muñoz-Carpena, and L. Yang, “High efficiency and selectivity of MgFe-LDH modified wheat-straw biochar in the removal of nitrate from aqueous solutions,” Journal of the Taiwan Institute of Chemical Engineers, vol. 63, pp. 312–317, 2016.

Full Text: PDF

DOI: 10.14416/j.asep.2023.08.002

Refbacks

  • There are currently no refbacks.


Copyright © 2024 by King Mongkut’s University of Technology North Bangkok. All rights reserved.