Page Header

Home > Vol 16, No 4 (Oct.–Dec. 2023) > Kiattisaksiri

Combination of Coagulation and VUV+H2O2 for the Treatment of Color and Organic Matter in Treated Effluent Wastewater from a Sugar Factory

Pradabduang Kiattisaksiri, Noppakhun Petmark, Thunyalux Ratpukdi

Abstract


The removal of color and organic matter in treated effluent wastewater from a sugar factory by coagulation, combined with advanced oxidation processes (AOPs), including UV, UV+ hydrogen peroxide (UV+H2O2), vacuum UV (VUV), and VUV+H2O2, was investigated in this study. The effect of pH and a dose of coagulants (aluminum sulfate (alum), polyaluminium chloride (PACl), ferric chloride (FeCl3), and ferric sulfate (Fe2(SO4)3)), as a pretreatment step prior to AOPs, was analyzed. The optimum pH and coagulant dose for coagulation was pH 6 and 600 mg/L, respectively. The iron-based coagulants generally provided the better removal efficiency than the aluminium-based coagulants. Among four coagulants, FeCl3 was chosen for use in the pretreatment step since it provided the best performance for dissolved organic carbon (DOC) removal, UV transmission improvement, and cost-effectiveness. The removal efficiency and degradation rate of color, UV absorbance at 254 nm (UV254), and DOC increased along with the H2O2 dosage. The reduction of UV254 indicated a less aromatic portion of DOC after AOPs. The ratio of DOC:H2O2 at 1:3 yielded the highest DOC removal of 70 ± 0.42 and 73 ± 0.19% in 60 min by UV+H2O2 and VUV+H2O2, respectively. For energy efficiency, VUV+H2O2 (DOC:H2O2 =1:3) provided the lowest electrical energy per order (EEO) (26 kWh/m3). After coagulation, DOC combined with VUV+H2O2 was reduced to the appropriate level for reuse (4 mg/L). The findings from this research demonstrate the promise of coagulation coupled with the VUV+H2O2 process as a technology for water reuse application in the sugar industry.

Keywords



[1] B. Gunjai and A. Gunjai, “Water conservation in sugar industry,” Nature Environment and Pollution Technology, vol. 12, pp. 325–330, 2013.
[2] O. P. Sahu and P. K. Chaudhari, “The characteristics, effects, and treatment of wastewater in sugarcane industry,” Water Quality, Exposure and Health, vol. 7, pp. 435–444, 2015.

[3] E. E. Ewa, A. I. Iwara, J. A. Adeyemi, E. I. Eja, A. O. Ajake, and C. A. Otu, “Impact of industrial activities on water quality of Omoku Creek,” Sacha Journal of Environmental Studies, vol. 1, pp. 8–16, 2011.

[4] M. Plavsic, B. Cosovic, and C. Lee, “Copper complexing properties of melanoidins and marine humic material,” Science of the Total Environment, vol. 366, pp. 310–319, 2006.

[5] O. P. Sahu and P. K. Chaudhari, “Electrochemical treatment of sugar industry wastewater: COD and color removal,” Journal of Electroanalytical Chemistry, vol. 739, pp. 122–129, 2015.

[6] H. K. Khalilova, S. A. Hasanova, and F. G. Aliyev, “Photocatalytic removal of organic pollutants from industrial wastewater using TiO2 catalyst,” Journal of Environmental Protection, vol. 9, pp. 691–698, 2018.

[7] A. L. Jembere and M. B. Genet, “Comparative adsorptive performance of adsorbents developed from sugar industrial wastes for the removal of melanoidin pigment from molasses distillery spent wash,” Water Resources and Industry, vol. 26, pp. 1–17, 2021.

[8] D. Bharathi, J. G. T. Nandagopal, R. Rajamani, S. Pandit, D. Kumar, B. Pant, S. Pandey, and P. K. Gupta, “Enhanced photocatalytic activity of St-ZnO nanorods for methylene blue dye degradation,” Materials Letters, vol. 311, pp. 1–4, 2022.

[9] H. K. Okoro, S. Pandey, C. O. Ogunkunle, C. J. Ngila, C. Zvinowanda, I. J. I. A. Lawal, M. M. Orosun, and A. G. Adeniyi, “Nanomaterial-based biosorbents: Adsorbent for efficient removal of selected organic pollutants from industrial wastewater,” Emerging Contaminants, vol. 8, pp. 46–58, 2022.

[10] M. Khapre, A. Shekhawat, D. Saravanan, S. Pandey, and R. Jugade, “Mesoporous Fe–Al–doped cellulose for the efficient removal of reactive dyes,” Materials Advances, vol. 3, pp. 3278–3285, 2022.

[11] S. Pandey, N. Son, and M. Kang, “Synergistic sorption performance of karaya gum crosslink poly(acrylamide-co-acrylonitrile) @ metal nanoparticle for organic pollutants,” International Journal of Biological Macromolecules, vol. 210, pp. 300–314, 2022.

[12] M. M. Momeni, D. Kahforoushan, F. Abbasi, and S. Ghanbarian, “Using Chitosan/CHPATC as coagulant to remove color and turbidity of industrial wastewater: Optimization through RSM design,” Journal of Environmental Management, vol. 211, pp. 347–355, 2018.

[13] P. Suwanvitaya and S. Singkharothai, “Control of trihalomethane precursors by alum coagulation,” Thai Environmental Engineering Journal, vol. 33, pp. 57–64, 2019.

[14] S. Usef and M. A. Ghalhari, “Optimization of turbidity removal by coagulation and flocculation process from synthetic stone cutting wastewater,” International Journal of Energy and Water Resources, vol. 3, pp. 33–41, 2019.

[15] I. M. Iloamaeke, N. J. Nnaji, E. C. Okpala, A. N. Eboatu, and T. U. Onuegbu, “Mercenaria mercenaria shell: Coagulation-flocculation studies on colour removal by response surface methodology and nephlometric kinetics of an industrial effluent,” Journal of Environmental Chemical Engineering, vol. 9, pp. 1–17, 2021.

[16] P. Puspita, F. A. Roddick, and N. A. Porter, “Decolourisation of secondary effluent by UVmediated processes,” Chemical Engineering Journal, vol. 171, pp. 464–473, 2011.

[17] P. Kiattisaksiri, E. Khan, P. Punyapalakul, C. Musikavong, D. C.W. Tsang, and T. Ratpukdi, “Vacuum ultraviolet irradiation for mitigating dissolved organic nitrogen and formation of haloacetonitriles,” Environmental Research, vol. 185, pp. 1–11, 2020.

[18] L. Long, Y. Bu, B. Chen, and R. Sadiq, “Removal of urea from swimming pool water by UV/VUV: The roles of additives, mechanisms, influencing factors, and reaction products,” Water Research, vol. 161, pp. 89–97, 2019.

[19] D. Krakkó, Á. Illés, A. Domján, A. Demeter, S. Dóbé, and G. Záray, “UV and (V)UV irradiation of sitagliptin in ultrapure water and WWTP effluent: Kinetics, transformation products and degradation pathway,” Chemosphere, vol. 288, pp. 1–11, 2022.

[20] M. G. Gonzalez, E. Oliveros, M. Wörner, and A. M. Braun, “Vacuum-ultraviolet photolysis of aqueous reaction systems,” Journal of Photochemistry and Photobiology C: Photochemistry Reviews, vol. 5, pp. 225–246, 2004. [21] K. Kutschera, H. Börnick, and E. Worch, “Photoinitiated oxidation of geosmin and 2-methylisoborneol by irradiation with 254 nm and 185 nm UV light,” Water Research, vol. 43, pp. 2224–2232, 2009.

[22] M. Umar, F. A. Roddick, and L. Fan, “Comparison of coagulation efficiency of aluminium and ferric-based coagulants as pretreatment for UVC/ H2O2 treatment of wastewater RO concentrate,” Chemical Engineering Journal, vol. 284, pp. 841–849, 2016.

[23] B. M. C. Filho, V. M. Silva, J. O. Silva, A. E. H. Machado, and A. G. Trovó, “Coupling coagulation, flocculation and decantation with photo-Fenton process for treatment of industrial wastewater containing fipronil: Biodegradability and toxicity assessment,” Journal of Environmental Management, vol. 174, pp. 71–78, 2016.

[24] J. R. Bolton, K. G. Bircher, W. Tumas, and C. A. Tolman, “Figures-of-merit for the technical development and application of advanced oxidation technologies for both electric- and solar-driven systems,” Pure and Applied Chemistry, vol. 73, pp. 627–637, 2001.

[25] S. S. Mohammed, “Effect of pH on the turbidity removal of wastewater, ” Open Access Library Journal, vol. 2, pp. 1–9, 2015.

[26] EPA, “Guidelines for water reuse,” CDM Smith Inc., Cincinnati, Ohio, Rep. EPA/600/R-12/618, 2012.

[27] L. Alcalde-Sanz and B. M. Gawlik, Minimum Quality Requirements for Water Reuse in Agricultural Irrigation and Aquifer Recharge - Towards a Water Reuse Regulatory Instrument at EU Level. Publications office of the European Union, Luxembourg, Rep. EUR 28962 EN, 2017.

[28] C. Shao, Y. Yang, Z. Liu, Q. Wang, Z. Ji, S. Wang, K. Demeestere, Y. Guo, and S. V. Hulle, “Characterization of landfill leachate by spectralbased surrogate measurements during a combination of different biological processes and activated carbon adsorption,” Water Science & Technology, vol. 81, no. 12, pp. 2606–2616, 2020.

[29] X. Chang, T. Lin, J. Mo, H. Xu, H. Tao, and W. Liu, “Coagulation combined with ultraviolet irradiation activated sodium percarbonate as pretreatment prior to ultrafiltration: Analysis of free radical oxidation mechanism and membrane fouling control,” Chemosphere, vol. 287, pp. 1–11, 2022.

[30] L. Fan, T. Nguyen, and F. A. Roddick, “Characterization of the impact of coagulation and anaerobic bio-treatment on the removal of chromophores from molasses wastewater,” Water Research, vol. 45, pp. 3933–3940, 2011.

[31] M. Sadrnourmohamadi and B. Gorczyca, “Removal of dissolved organic carbon (DOC) from high DOC and hardness water by chemical coagulation–relative importance of monomeric, polymeric and colloidal aluminum species,” Separation Science and Technology, vol. 50, pp. 2075–2085, 2015.

[32] D. Cruz, M. Pimentel, A. Russo, and W. Cabral, “Charge neutralization mechanism efficiency in water with high color turbidity ratio using aluminium sulfate and flocculation Index,” Water, vol. 12, pp. 2–17, 2020.

[33] K. Saxena, U. Brighu, and A. Choudhary, “Parameters affecting enhanced coagulation: A review,” Environmental Technology Reviews, vol. 7, pp. 156–176, 2018.

[34] H. Zhao, H. Liu, and J. Qu, “Effect of pH on the aluminum salts hydrolysis during coagulation process: Formation and decomposition of polymeric aluminum species,” Journal of Colloid and Interface Science, vol. 330, pp. 105–112, 2009.

[35] WHO, A Compendium of Standards for Wastewater Reuse in the Eastern Mediterranean Region. Regional office for the Eastern Mediterranean, Cairo, Egypt, Rep. WHO-EM/CEH/142/E, 2006.

[36] A. Y. Bagastyo, J. Keller, Y. Poussade, and D. J. Batstone, “Characterisation and removal of recalcitrants in reverse osmosis concentrates from water reclamation plants,” Water Research, vol. 45, pp. 2415–2427, 2011.

[37] F. Qian, M. He, J. Wu, H. Yu, and L. Duan, “Insight into removal of dissolved organic matter in post pharmaceutical wastewater by coagulation-UV/H2O2,” Journal of Environmental Sciences, vol. 76, pp. 329–338, 2019.

[38] G. G. Bessegato, J. C. Souza, J. C. Cardoso, and M. V. B. Zanoni, “Assessment of several advanced oxidation processes applied in the treatment of environmental concern constituents from a real hair dye wastewater, ” Journal of Environmental Chemical Engineering, vol. 6, pp. 2794–2802, 2018.

[39] C. H. Jo, A. M. Dietrich, and J. M. Tanko, “Simultaneous degradation of disinfection byproducts and earthy-musty odorants by the UV/H2O2 advanced oxidation process,” Water Research, vol. 45, pp. 2507–2516, 2011.

[40] G. Imoberdorf and M. Mohseni, “Experimental study of the degradation of 2,4-D induced by vacuum-UV radiation,” Water Science & Technology, vol. 63, no. 7, pp. 1427–1433, 2011.

[41] D. Wang, C. Wang, M. Ji, L. Sun, C. Qiu, and S. Lo, “Characterization of dissolved organic matter removal during biological treatment of commingled chemical industrial wastewater: Relationship with fluorescent dissolved organic matter transformation,” Polish Journal of Environmental Studies, vol. 29, pp. 307–322, 2020.

[42] M. Nihemaiti, D. B. Miklos, U. Hübner, K. G. Linden, J. E. Drewes, and J. P. Croué, “Removal of trace organic chemicals in wastewater effluent by UV/ H2O2 and UV/PDS,” Water Research, vol. 145, pp. 487–497, 2018.

[43] G. Moussavi, E. Fathi, and M. Moradi, “Advanced disinfecting and post-treating the biologically treated hospital wastewater in the UVC/H2O2 and VUV/H2O2 processes: Performance comparison and detoxification efficiency,” Process Safety and Environmental Protection, vol. 126, pp. 259–268, 2019.

[44] T. Ratpukdi, S. Siripattanakul, and E. Khan, “Mineralization and biodegradability enhancement of natural organic matter by ozone-VUV in comparison with ozone, VUV, ozone-UV, and UV: Effects of pH and ozone dose,” Water Research, vol. 44, pp. 3531–3543, 2010.

[45] D. Gerrity, E. Owens-Bennett, T. Venezia, B. D. Stanford, M. H. Plumlee, J. Debroux, and R. S. Trussell, “Applicability of ozone and biological activated carbon for potable reuse,” Ozone: Science & Engineering, vol. 36, pp. 123– 137, 2014.

Full Text: PDF

DOI: 10.14416/j.asep.2022.08.002

Refbacks

  • There are currently no refbacks.


Copyright © 2024 by King Mongkut’s University of Technology North Bangkok. All rights reserved.