Page Header

Home > Vol 15, No 4 (Oct.–Dec. 2022) > Suwannatrai

Zeolite/Cerium Oxide Coat-on Activated Alumina Ball for Arsenite Removal via Fixed- Bed Continuous Flow Adsorption Column

Suttikorn Suwannatrai, Dickson Y. S. Yan, Pummarin Khamdahsag, Visanu Tanboonchuy

Abstract


Arsenite (As(III)) has threatened human life for ages. It is a necessity to remove As(III) from the contaminated water before general use. With the improvement of adsorption, higher As(III) removal can be achieved. This study aimed to develop zeolite/cerium oxide coat-on activated alumina ball adsorbent (CeZ-ball) with the aid of PVA binder and apply it to a fixed-bed continuous flow column for As(III) adsorption. The coating percentage of CeZ-ball was studied. Cerium ions leaching from CeZ-ball were monitored throughout the 2,880-min-column run to confirm the stability of CeZ attached to an activated alumina ball. Surface area, pH point of zero charge, and structural property of CeZ-ball were characterized. An average CeZ coating of 83.3% and rare leaching of cerium proved the coating method. The models proposed by Yoon-Nelson provided the most satisfactory fit with the breakthrough curve (r2 = 0.985, MPSD = 2.547, and q0 = 3.481 mg·g–1) under experimental conditions of the flow rate of 5 mL·min–1, As(III) influent concentration of 1 mg·L–1, and CeZ-ball weight of 40 g. The half-time of breakthrough (τ) was 1,228.739 min. The effects of the key parameters, including initial adsorbent weight, initial flow rate, and initial As(III) concentration, were investigated for the performance of As(III) adsorption. Simulated from the Yoon-Nelson model, the τ increased as well as the adsorbent weight but decreased as the flow rate increased, thus impacting the As(III) concentration. With the optimal condition, the fixed-bed continuous column with CeZ-ball could be used in As(III) removal from contaminated water.

Keywords



[1] Y. Xiong, Q. Tong, W. Shan, Z. Xing, Y. Wang, and S. Wen, “Arsenic transformation and adsorption by iron hydroxide/manganese dioxide doped straw activated carbon,” Applied Surface Science, vol. 416, pp. 618–627, 2017.

[2] Z. Wen, Y. Zhang, X. Zhou, and R. Chen, “Effective As(III) and As(V) immobilization from aqueous solution by nascent ferrous hydroxide colloids (FHC),” Separation and Purification Technology, vol. 176, pp. 395–401, 2017.

[3] R. Yadav, A. K. Sharma, and J. N. Babu, “Sorptive removal of arsenite [As(III)] and arsenate [As(V)] by fuller’s earth immobilized nanoscale zero-valent iron nanoparticles (F-nZVI): Effect of Fe0 loading on adsorption activity,” Journal of Environmental Chemical Engineering, vol. 4, no. 1, pp. 681–694, 2016.

[4] C. Zihang, F. Fu, D. D. Dionysiou, and B. Tang, “Adsorption, oxidation, and reduction behavior of arsenic in the removal of aqueous As(III) by mesoporous Fe/Al bimetallic particles,” Water Research, vol. 96, pp. 22–31, 2016.

[5] H. Zongliang, S. Tian, and N. Ping, “Adsorption of arsenate and arsenite from aqueous solutions by cerium-loaded cation exchange resin,” Journal of Rare Earths, vol. 30, no. 6, pp. 563–572, 2012.

[6] A. Sadiya, S. Shafinaz, I. Norahim, J. N. Mohammed, D. V. N. Vo, and F. A. Manan, “Arsenic removal technologies and future trends: A mini review,” Journal of Cleaner Production, vol. 278, p. 123805, 2021.

[7] D. Liu, S. Deng, A. Maimaiti, B. Wang, J. Huang, Y. Wang, and G. Yu, “As(III) and As(V) adsorption on nanocomposite of hydrated zirconium oxide coated carbon nanotubes,” Journal of Colloid and Interface Science, vol. 511, pp. 277–284, 2018.
[8] G. Zhang, J. Qu, H. Liu, R. Liu, and R. Wu, “Preparation and evaluation of a novel Fe-Mn binary oxide adsorbent for effective arsenite removal,” Water Research, vol. 41, no. 9, pp. 1921– 1928, 2007.

[9] B. Rathi, J. Jamieson, J. sun, A. J. Siade, M. Zhu, O. A. Cirpka, and H. Prommer, “Process-based modeling of arsenic(III) oxidation by manganese oxides under circumneutral pH conditions,” Water Research, vol. 185, 2020, Art. no. 11695.

[10] L. Zhang, T. Zhu, X. Liu, and W. Zhang, “Simultaneous oxidation and adsorption of As(III) from water by cerium modified chitosan ultrafine nanobiosorbent,” Journal of Hazardous Materials, vol. 308, pp. 1–10, 2016.

[11] M. Biterna, L. Antonoglou, E. Lazou, and D. Voutsa, “Arsenite removal from waters by zero valent iron: Batch and column tests,” Chemosphere, vol. 78, no. 1, pp. 7–12, 2010.

[12] D. Dickson, G. Liu, and Y. Cai, “Adsorption kinetics and isotherms of arsenite and arsenate on hematite nanoparticles and aggregates,” Journal of Environmental Management, vol. 186, pp. 261– 267, 2017.

[13] C. Luengo, V. Puccia, and M. Avena, “Arsenate adsorption and desorption kinetics on a Fe(III)- modified montmorillonite,” Journal of Hazardous Materials, vol. 186, no. 2–3, pp. 1713–1719, 2011.

[14] W. Sun, Q. Li, S. Gao, and J. K. Shang, “Exceptional arsenic adsorption performance of hydrous cerium oxide nanoparticles: Part B. Integration with silica monoliths and dynamic treatment,” Chemical Engineering Journal, vol. 185–186, pp. 136–143, 2012.

[15] S. Suwannatrai, D. Y. S. Yan, J. Phanthasri, P. Khamdahsag, S. Wannapaiboon, and V. Tanboonchuy, “Oxidation-adsorption of arsenite contaminated water over ceria nanorods,” Desalination and Water Treatment, vol. 200, pp. 252–261, 2020.
[16] Y. L. Yang, Y. J. Li, Y. H. Yuan, R. P. Liang, and J. D. Qiu, “Target induced aggergation of Ce(III)-based coordination polymer nanoperticles for fluorimertric detection of As(III),” Talanta, vol. 190, pp. 255–262, 2018.

[17] Z. Li, L. Wang, J. Meng, X. Liu, J. Xu, and F. Wang, “Zeolite-supported nanoscale zero-valent iron: New findings on simultaneous adsorption of Cd(II), Pb(II), and As(III) in aqueous solution and soil,” Journal of Hazardous Materials, vol. 344, pp. 1–11, 2018.

[18] J. Phanthasri, N. Grisdanurak, P. Khamdahsag, K. Wantala, R. Khunphonoi, S. Wannapaiboon, and V. Tanboonchuy, “Role of zeolite-supported nanoscale zero-valent iron in selenate removal,” Water, Air, and Soil Pollution, vol. 231, no. 5, pp. 1–12, 2020.

[19] W. Chansiriwat, D. Tanangteerapong, and K. Wantala, “Synthesis of zeolite from coal fly ash by hydrothermal method without adding alumina and silica sources: Effect of aging temperature and time,” Sains Malaysiana, vol. 45, no. 11, pp. 1723–1731, 2016.

[20] H. Yin, M. Kong, X. Gu, and H. Chen, “Removal of arsenic from water by porous charred franulated attapulgite-supported hydrated iron oxide in bath and column modes,” Journal of Cleaner Production, vol. 166, pp. 88–97, 2017.

[21] S. Cheng, L. Zhang, A. Ma, H. Xia, J. Peng, C. Li, and J. Shu, “Comparison of activated carbon and iron/cerium modified activated carbon to remove methylene blue from wastewater,” Journal of Environmental Science, vol. 5, pp. 1–11, 2017.
[22] S. Chen, Q. Yue, B. Gao, Q. Li, X. Xu, and K. Fu, “Adsorption of hexavalent chromium from aqueous solution by modified corn stalk: A fixed bed column study,” Bioresource Technology, vol. 113, pp. 114–120, 2012.

[23] H. C. Thomas, “Heterogeneous ion exchange in a flowing system,” Journal of the American Chemical Society, vol. 66, no. 10, pp. 1664–1666, 1944.

[24] P. Dhanasekaran, P. M. S. Sai, and K. I. Gnanasekar, “Fixed bed adsorption of fluoride by Artocarpus hirsutus based adsorbent,” Journal of Fluorine Chemistry, vol. 195, pp. 37–46, 2017.

[25] Y. Dong and H. Lin, “Competitive adsorption of Pb(II) and Zn(II) from aqueous solution by modified beer lees in a fixed bed column,” Process Safety and Environmental Protection, vol. 1, no. 111, pp. 263–269, 2017.

[26] M. Trgo, N. V. Medvidović, and J. Perić, “Application of mathematical empirical models to dynamic removal of lead on natural zeolite clinoptilolite in a fixed bed column,” Indian Journal of Chemical Technology, vol. 18, no. 2, pp. 123–131, 2011.

[27] J. Cruz-Olivares, C. Pérez-Alonso, C. Barrera- Díaz, F. Ureña-Nuñez, M. C. Chaparro-Mercado, and B. Bilyeu, “Modeling of lead(II) biosorption by residue of allspice in a fixed-bed column,” Chemical Engineering Journal, vol. 228, pp. 21– 27, 2013.

[28] Y. Long, D. Lei, J. Ni, Z. Ren, C. Chen, and H. Xu, “Packed bed column studies on lead(II) removal from industrial wastewater by modified Agaricus bisporus,” Bioresource Technology, vol. 152, pp. 457–463, 2014.

[29] R. Brion-Roby, J. Gagnon, J. S. Debastien, and B. Chabot, “Investigation of fixed bed adsorption column operation parameters using a chitosan material for treatment of arsenate contaminated water,” Journal of Environmental Chemical Emgineering, vol. 6, pp. 505–511, 2018.

[30] M. V. Sergio, I. M. Arturo, E. H. B. Elias, F. M. R. Oscar, V. H. Virgilio, P. C. Cristobal, and L. L. Jaime, “As(III) and As(V) adsorption on manganese ferrite nanoparticles,” Journal of Molecular Structure, vol. 1154, pp. 524–534, 2018.

[31] F. Fadzil, S. Ibrahim, and M. A. K. M. Hanafiah, “Adsorption of lead(II) onto organic acid modified rubber leaf powder: Batch and column studies,” Process Safety and Environmental Protection, vol. 100, pp. 1–8, 2016.

[32] D. Jiang, Y. Amano, and M. Machida, “Removal and recovery of phosphate from water by a magnetic Fe3O4 @ASC adsorbent,” Journal of Environmental Chemical Engineering, vol. 5, no. 5, pp. 4229–4238, 2017.

[33] S. Kundu and A. K. Gupta, “As(III) removal from aqueous medium in fixed bed using iron oxide-coated cement (IOCC): Experimental and modeling studies,” Chemical Engineering Journal, vol.129, pp. 123–131, 2007.

[34] N. Zhu, J. Qiao, Y. Ye, and T. Yan, “Synthesis of mesoporous bismuth-impregnated aluminum oxide for arsenic removal: Adsorption mechanism study and application to a lab-scale column,” Journal of Environmental Management, vol. 211, pp.73–82, 2018.

[35] S. A. Baig, J. Zhu, L. Tan, X. Xue, C. Sun, and X. Xinhua, “Influence of calcination on magnetic honeycomb briquette cinders composite for the adsorptive removal of As(III) in fixed-bed column,” Chemical Engineering Journal, vol. 257, pp. 1–9, 2014.

[36] I. Ali, “Microwave assisted economic synthesis of multi walled carbon nanotubes for arsenic species removal in water: Batch and column operation,” Journal of Molecular Liquids, vol. 271, pp. 677–685, 2018.

Full Text: PDF

DOI: 10.14416/j.asep.2021.11.004

Refbacks

  • There are currently no refbacks.


Copyright © 2024 by King Mongkut’s University of Technology North Bangkok. All rights reserved.